Mercedes C-Class

W203 since 2000 of release

Repair and operation of the car


Mercedes-Benz
+ Mercedes-Benz cars of class C (W-203)
+ Operation manual
+ Routine maintenance
+ Engine
+ Cooling system and heating
+ Power supply system and release
- Engine electric equipment
   + System of ignition and engine management
   + System of preheat of the diesel engine
   + Diagnostics of systems of electronic control and diagnostic equipment
   - Systems of a charge and start
      The rechargeable battery - the main data and acquisition of the new battery
      Check and charging of the rechargeable battery
      Replacement of the rechargeable battery
      Storage of the rechargeable battery
      System of charging - general information and security measures
      Check of system of charging
      Removal and installation of the generator
      Removal and installation of the regulator of tension. Replacement of brushes
      System of start of the engine - the general information and precautionary measures
      Removal and installation of a starter
      Removal and installation of the traction relay of a starter
      Check of system of start of the engine
+ Manual transmission
+ Automatic transmission
+ Coupling and power shafts
+ Brake system
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment

Автоматический рефрактометр по материалам сайта.

Removal and installation of a starter

The electric motor called by a starter is necessary for start of the internal combustion engine. That the engine of the car started working, it is necessary to untwist it it to speed not less than 300 rpm. It is possible to reach it if the starter reliably works and the rechargeable battery is charged.

As start of the engine requires big electricity consumption, when carrying out maintenance it is necessary to pay attention to reliable connection of cables. The contacts having a rust need to be smoothed out and greased with jellied lubricant.

Removal

 PERFORMANCE ORDER

1. Disconnect a negative cable (-) of the rechargeable battery at vyklyuchyonny ignition. It is previously necessary to remove a box of the filter of air of salon.

Before a detachment of a cable find out a protective code of the radio receiver if that is available, address the Section Replacement of the Rechargeable Battery.

Do not connect the auxiliary power supply.

2. Lift and establish a forward part of the car on supports.

 Lifting operation and installations of the car on supports is connected with danger! Therefore before carrying out operation study Poddomkrachivaniye's Section and towage of Introduction to the management.

3. Uncover the bottom, address the Section Removal and installation of a cover of a motive compartment from the bottom.
4. Engine 112: Remove system of production of the fulfilled gases.

5. Turn off nuts (1) and disconnect electric wires from a starter.

6. Turn out 2 screws (2) on a starter.
7. Take aside a cable plait with the holder and take out a starter from a motive compartment down.